AIR CONDITIONING UNIT > INSTALLATION

1. TEMPORARILY TIGHTEN AIR CONDITIONING UNIT ASSEMBLY

2. INSTALL INSTRUMENT PANEL REINFORCEMENT ASSEMBLY

3. INSTALL AIR CONDITIONING UNIT ASSEMBLY

4. INSTALL NO. 3 AIR DUCT SUB-ASSEMBLY

5. INSTALL LOWER DEFROSTER NOZZLE ASSEMBLY

6. INSTALL DEFROSTER NOZZLE ASSEMBLY

7. INSTALL NO. 2 INSTRUMENT PANEL BRACE SUB-ASSEMBLY

8. INSTALL NO. 1 INSTRUMENT PANEL BRACE SUB-ASSEMBLY

9. INSTALL NO. 3 SIDE DEFROSTER NOZZLE DUCT

10. INSTALL REAR NO. 1 AIR DUCT

11. INSTALL REAR NO. 3 AIR DUCT

12. INSTALL REAR NO. 2 AIR DUCT

13. INSTALL STEERING POST ASSEMBLY

14. CONNECT NO. 2 STEERING INTERMEDIATE SHAFT ASSEMBLY

15. INSTALL COLUMN HOLE COVER SILENCER SHEET

16. INSTALL NO. 2 AIR DUCT SUB-ASSEMBLY

17. INSTALL BRAKE PEDAL SUPPORT ASSEMBLY

18. INSTALL PUSH ROD PIN

19. INSTALL BRAKE PEDAL RETURN SPRING

20. INSTALL STOP LIGHT SWITCH MOUNTING ADJUSTER

21. INSTALL STOP LIGHT SWITCH ASSEMBLY

22. INSTALL DRIVER SIDE JUNCTION BLOCK ASSEMBLY (for LHD)

23. INSTALL FRONT PASSENGER SIDE JUNCTION BLOCK ASSEMBLY (for RHD)

24. INSTALL ECU INTEGRATION BOX LH (for RHD)

25. INSTALL HEADUP DISPLAY

26. INSTALL LOWER INSTRUMENT PANEL SUB-ASSEMBLY (for LHD)

27. INSTALL LOWER INSTRUMENT PANEL SUB-ASSEMBLY (for RHD)

28. INSTALL NO. 2 ANTENNA CORD SUB-ASSEMBLY (for LHD)

29. INSTALL NO. 2 ANTENNA CORD SUB-ASSEMBLY (for RHD)

30. INSTALL POWER STEERING ECU ASSEMBLY

31. INSTALL COMBINATION METER ASSEMBLY

32. INSTALL NO. 1 HEATER TO REGISTER DUCT

33. INSTALL COWL SIDE TRIM BOARD RH

34. INSTALL FRONT DOOR SCUFF PLATE RH

35. INSTALL GLOVE COMPARTMENT DOOR ASSEMBLY

36. INSTALL NO. 2 INSTRUMENT PANEL UNDER COVER SUB-ASSEMBLY

37. INSTALL DRIVER SIDE KNEE AIRBAG ASSEMBLY

38. INSTALL NO. 1 INSTRUMENT PANEL UNDER COVER SUB-ASSEMBLY (for LHD)

39. INSTALL NO. 1 INSTRUMENT PANEL UNDER COVER SUB-ASSEMBLY (for RHD)

40. ALIGN FRONT WHEELS FACING STRAIGHT AHEAD

41. INSTALL TURN SIGNAL SWITCH ASSEMBLY WITH SPIRAL CABLE SUB-ASSEMBLY

42. INSTALL UPPER STEERING COLUMN COVER

43. INSTALL LOWER STEERING COLUMN COVER

44. INSTALL STEERING WHEEL ASSEMBLY

45. INSTALL STEERING PAD

46. INSTALL LOWER NO. 3 STEERING WHEEL COVER

47. INSTALL LOWER NO. 2 STEERING WHEEL COVER

48. INSTALL NO. 1 SWITCH HOLE BASE

49. INSTALL UPPER INSTRUMENT PANEL FINISH PANEL ASSEMBLY

50. INSTALL SHIFT LOCK CONTROL UNIT ASSEMBLY

51. INSTALL AIR CONDITIONING CONTROL ASSEMBLY

52. INSTALL CONSOLE BOX ASSEMBLY

53. INSTALL BOX BOTTOM MAT

54. INSTALL FRONT NO. 2 CONSOLE BOX INSERT

55. INSTALL FRONT NO. 1 CONSOLE BOX INSERT

56. INSTALL NO. 2 CONSOLE BOX MOUNTING BRACKET

57. INSTALL ELECTRICAL KEY OSCILLATOR

58. INSTALL REAR CONSOLE BOX ASSEMBLY

59. INSTALL CONSOLE BOX CARPET

60. INSTALL REAR CONSOLE BOX CUP HOLDER

61. INSTALL UPPER INSTRUMENT PANEL ASSEMBLY

62. CONNECT NO. 3 INSTRUMENT PANEL WIRE

63. INSTALL CENTER INSTRUMENT CLUSTER FINISH PANEL GARNISH

64. INSTALL INSTRUMENT CLUSTER FINISH PANEL END

65. INSTALL FRONT NO. 2 SPEAKER ASSEMBLY

66. INSTALL NO. 2 INSTRUMENT PANEL SPEAKER PANEL SUB-ASSEMBLY

67. INSTALL FRONT PILLAR GARNISH CORNER PIECE RH

68. INSTALL FRONT PILLAR GARNISH RH

69. INSTALL FRONT NO. 2 SPEAKER ASSEMBLY

70. INSTALL NO. 1 INSTRUMENT PANEL SPEAKER PANEL SUB-ASSEMBLY

71. INSTALL FRONT PILLAR GARNISH CORNER PIECE LH

72. INSTALL FRONT PILLAR GARNISH LH

73. INSTALL INSTRUMENT PANEL FINISH PANEL END RH

74. CONNECT FRONT DOOR OPENING TRIM WEATHERSTRIP RH

75. INSTALL GLOVE COMPARTMENT DOOR

76. INSTALL NO. 2 INSTRUMENT PANEL REGISTER

77. INSTALL NO. 1 SIDE DEFROSTER NOZZLE

78. INSTALL INSTRUMENT PANEL FINISH PANEL END LH

79. CONNECT FRONT DOOR OPENING TRIM WEATHERSTRIP LH

80. INSTALL NO. 1 CENTER INSTRUMENT CLUSTER FINISH PANEL

81. INSTALL NO. 1 INSTRUMENT PANEL REGISTER

82. INSTALL LOWER INSTRUMENT PANEL FINISH PANEL ASSEMBLY

83. INSTALL COWL SIDE TRIM SUB-ASSEMBLY LH

84. INSTALL FRONT DOOR SCUFF PLATE LH

85. INSTALL NAVIGATION RECEIVER WITH BRACKET (for Navigation Receiver Type)

86. INSTALL RADIO AND DISPLAY RECEIVER ASSEMBLY WITH BRACKET (for Radio and Display Type)

87. INSTALL RADIO TUNER OPENING COVER WITH BRACKET (w/o Radio Receiver)

88. INSTALL CENTER INSTRUMENT CLUSTER FINISH PANEL SUB-ASSEMBLY (w/o Radio Receiver)

89. INSTALL UPPER INSTRUMENT PANEL FINISH PANEL SUB-ASSEMBLY

90. INSTALL INSTRUMENT CLUSTER FINISH PANEL GARNISH

91. INSTALL LOWER CENTER INSTRUMENT CLUSTER FINISH PANEL SUB-ASSEMBLY

92. INSTALL INTEGRATION CONTROL AND PANEL ASSEMBLY

93. CONNECT OUTLET HEATER WATER HOSE

94. CONNECT INLET HEATER WATER HOSE

95. CONNECT AIR CONDITIONING TUBE AND ACCESSORY ASSEMBLY

96. CONNECT SUCTION PIPE SUB-ASSEMBLY

97. INSTALL OUTER COWL TOP PANEL SUB-ASSEMBLY (for LHD)

98. INSTALL OUTER COWL TOP PANEL SUB-ASSEMBLY (for RHD)

99. INSTALL COWL BODY MOUNTING REINFORCEMENT LH (for LHD)

100. INSTALL COWL BODY MOUNTING REINFORCEMENT LH (for RHD)

101. INSTALL WINDSHIELD WIPER MOTOR AND LINK ASSEMBLY

102. INSTALL COWL TOP VENTILATOR LOUVER SUB-ASSEMBLY (for LHD)

103. INSTALL COWL TOP VENTILATOR LOUVER SUB-ASSEMBLY (for RHD)

104. INSTALL COWL SIDE VENTILATOR SUB-ASSEMBLY LH

105. INSTALL COWL SIDE VENTILATOR SUB-ASSEMBLY RH

106. INSTALL FRONT WIPER ARM AND BLADE ASSEMBLY RH

107. INSTALL FRONT WIPER ARM AND BLADE ASSEMBLY LH

108. INSTALL FRONT WIPER ARM HEAD CAP

109. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL

110. INSTALL REAR NO. 3 FLOOR BOARD

111. INSTALL REAR DECK FLOOR BOX

112. INSTALL REAR NO. 2 FLOOR BOARD

113. ADD COOLANT (for Engine)

114. CHARGE WITH REFRIGERANT

115. WARM UP COMPRESSOR

116. INSPECT FOR REFRIGERANT LEAK

117. INSPECT FOR COOLANT LEAK (for Engine)

118. INSPECT SHIFT LEVER

119. INSPECT STEERING PAD

120. INSPECT SRS WARNING LIGHT